Hyundai Sonata: Heater Unit Components and Components Location - Heater - Heating, Ventilation and Air ConditioningHyundai Sonata: Heater Unit Components and Components Location

Component Location

1. Heater unit assembly


Compoents (1)

1. Mode actuator
2. Mode bracket plate
3. Mine link plate
4. Temperature control actuator [LH]
5. Washer
6. Face door lever
7. Foot & Defrost midole lever
8. Servo lever arm [LH]
9. Door lever arm [LH]
10. Foot & Defrost door lever [LH]
11. Shower duct [LH]
12. Heater core bracket
13. Rear heater duct seal [LH]
14. Speed nut
15. Adaptor heater case [LH]
16. Rear console duct seal
17. Heater case [LH]
18. Center duct seal
19. Heater core & Seal assembly
20. Defroster door assembly
21. Vent door assembly
22. Floor door assembly
23. Temperature door assembly
24. Heater unit pad
25. Separator
26. Adaptor heater case [RH]
27. Heater case [RH]
28. Rear heater duct seal [RH]
29. Door lever arm [RH]
30. Servo lever arm [RH]
31. Aspirator assembly
32. Drain hose
33. Heater lower cover
34. Evaporator sub assembly
35. Temperature control actuator [RH]
36. Evaporator thermistor sub assembly
37. Shower duct [RH]

    Heater
    ...

    Heater Unit Repair procedures
    Replacement     When prying with a flat-tip screwdriver or use a prying trim tool, wrap it with protective tape, and apply protective tape around the related parts, to prevent ...

    See also:

    General Information
    General Troubleshooting Information Before Troubleshooting 1. Check applicable fuses in the appropriate fuse/relay box. 2. Check the battery for damage, state of charge, and clean and tight c ...

    SRS Control Module (SRSCM). Repair procedures
    Removal 1. Remove the ignition key from the vehicle. 2. Disconnect the battery negative cable and wait for at least three minutes before b ...

    Ignition key interlock system
    The ignition key cannot be removed unless the shift lever is in the P (Park) position. If the ignition switch is in any other position, the key cannot be removed. ...