Hyundai Sonata: Intercooler Repair procedures - Intake And Exhaust System - Engine Mechanical SystemHyundai Sonata: Intercooler Repair procedures

Removal and Installation
1.
Disconnect the battery negative terminal.
2.
Remove the intercooler inlet hoses & pipe (A).

Tightening torque
Bolt :
19.6 ~ 26.4 N.m (2.0 ~ 2.7 kgf.m, 14.4 ~ 19.5 lb-ft)
Clamp :
4.9 ~ 6.8 N.m (0.5 ~ 0.7 kgf.m, 3.6 ~ 5.0 lb-ft)

3.
Remove the intercooler outlet hose (A).

Tightening torque:
4.9 ~ 6.8 N.m (0.5 ~ 0.7 kgf.m, 3.6 ~ 5.0 lb-ft)

4.
Remove the front bumper cover. (Refer to Body - "Front Bumper")
5.
Remove the intercooler air guard(A).

6.
Disconnect the boost pressure sensor connector (A) RCV solenoid valve connector(B).
7.
Disconnect the vacuum hose (C).

8.
Remve the intercooler uper mounting bracket(A) and then remove the intercooler(B).

Tightening torque:
3.9 ~ 5.7 N.m (0.4 ~ 0.6 kgf.m, 2.9 ~ 4.2 Ib-ft)

9.
Install in the reverse order of removal.
    Intercooler Components and Components Location
    Components 1. Intercooler air guard2. Intercooler3. Intercooler outlet hose4. Intercooler inlet hose & pipe5. Intercooler upper mounting bracket6. Intercooler lower mounting insulator7. Inter ...

    Turbo Charger Components and Components Location
    Components 1. Turbine housing2. Turbine inlet3. Turbine outlet4. Compressor housing5. Compressor inlet6. Compressor outlet7. Center housing8. Actuator9. Actuator rod ...

    See also:

    Front Driveshaft. Repair procedures - Revised
    Replacement 1. Loosen the wheel nuts slightly. Raise the vehicle, and make sure it is securely supported. 2. Remove the front wheel and ...

    Jack and tools
    The jack, jack handle, and wheel lug nut wrench are stored in the luggage compartment. Pull up the luggage box cover to reach this equipment. (1) Jack handle (2) Jack (3) Wheel lug nut wrench ...

    Components and Components Location
    Components [Manual Seat Type] 1. Front seat headrest2. Front seat headrest guide3. Front seat back board4. Front seat back frame assembly5. Front seat back pad6. Front seat back heater7. Front ...