Hyundai Sonata: Rear Door Window Glass Repair procedures - Rear Door - Body (Interior and Exterior)Hyundai Sonata: Rear Door Window Glass Repair procedures

Replacement
1.
Pull down rear door window glass by pressing the power window glass switch.
2.
Remove the rear door trim.
(Refer to Rear Door - "Rear Door Trim")
3.
Remove the rear door belt outside weatherstrip (A).

4.
After loosening the mounting screws, then remove the rear door delta garnish (A).

5.
Completely loosen the rear door channel mounting bolt and loosen the nuts as much as you can without the nuts removed from the rear door panel.

Tightening torque :
Bolt: 6.9 ~ 10.8 N.m (0.7 ~ 1.1 kgf.m, 5.1 ~ 8.0 lb-ft)
Nut: 3.9 ~ 5.9 N.m (0.4 ~ 0.6 kgf.m, 2.9 ~ 4.3 lb-ft)

6.
Slightly push the rear door channel like the direction of the arrow in the picture below.

7.
Remove the rear door window glass mounting hole plug (A).

8.
Carefully adjust the rear door window glass (A) until you can see the bolt, then loosen them. Separate the glass from the glass run and carefully pull the glass out through the window slot.

Tightening torque :
7.8 ~ 11.8 N.m (0.8 ~ 1.2 kgf.m, 5.8 ~ 8.7 lb-ft)

   
Be careful not to drop the glass and/or scratch the glass surface.
   
Use the door switch to align the mounting hole/bolt with the hole in the door.
If unable to operate the window motor, remove the motor and align the hole by hand.
9.
Install in the reverse order of removal.
   
Roll the glass up and down to see if it moves freely without binding.
Adjust glass position as needed.
Make sure the door lock and opens properly.
Replace any damaged clips.
    Rear Door Window Glass Components and Components Location
    Component Location 1. Rear door window glass ...

    Rear Door Module Components and Components Location
    Component Location 1. Rear door module ...

    See also:

    TPMS (Tire Pressure Monitoring System) malfunction indicator
    The TPMS malfunction indicator will illuminate after it blinks for approximately one minute when there is a problem with the Tire Pressure Monitoring System. If the system is able to correctly d ...

    Power Door Lock Actuators. Repair procedures
    Inspection Front Door Lock Actuator Inspection 1. Remove the front door trim. (Refer to the BD group - "Front door") 2. R ...

    Battery Components and Components Location
    Components 1. Battery insulation pad2. Battery3. Battery tray4. Battery mounting bracket ...