Hyundai Sonata: Side Airbag (SAB) Module Repair procedures - Airbag Module - RestraintHyundai Sonata: Side Airbag (SAB) Module Repair procedures

Removal
   
The side airbag cannot be disassembled from the seat back assembly, so replace the seat back assembly when replacing the side airbag.
1.
Disconnect the battery negative cable and wait for at least 3 minutes before beginning work.
2.
Remove the front seat assembly.
(Refer to Body - "Front Seat Assembly")
3.
Remove the seat back assembly.
(Refer to Body - "Front Seat Back Assembly")
4.
Loosen the SAB mounting nuts (A) and remove the SAB module.

Installation
   
Be sure to install the harness wires so they will not pinch or interfere with other parts.
   
Do not open the lid of the side airbag cover.
Make sure that the airbag assembly cover is installed properly. Improper installation may prevent the proper deployment.
1.
Remove the ignition key from the vehicle.
2.
Disconnect the battery negative cable and wait for at least three minutes.
3.
Install the new seat back assembly.
(Refer to Body - "Front Seat Back Assembly")
4.
Install the front seat assembly.
(Refer to Body - "Front Seat Assembly")
5.
Recline and slide the front seat forward fully, make sure the harness wires are not pinched of interfere with other parts.
6.
Reconnect the battery negative cable.
7.
After installing the side airbag (SAB), confirm proper system operation :
A.
Turn the ignition switch ON; the SRS indicator light should be turned on for about six seconds and then go off.
    Curtain Airbag (CAB) Module Description and Operation
    Description Curtain airbags are installed inside the headliner (LH and RH) and protect the driver and passenger from danger when side crash occurs. The SRSCM determines deployment of curtain ai ...

    See also:

    Camshaft Position Sensor (CMPS). Schematic Diagrams
    Circuit Diagram ...

    Radial-ply tires
    Radial-ply tires provide improved tread life, road hazard resistance and smoother high speed ride. The radial- ply tires used on this vehicle are of belted construction, and are selected to comple ...

    Fuel Pressure Control Valve Troubleshooting
    Signal Waveform ...