Hyundai Sonata: Water pump Troubleshooting - Cooling System - Engine Mechanical SystemHyundai Sonata: Water pump Troubleshooting

Troubleshooting
Symptoms
Possible Causes
Remedy
Coolant leakage
From the bleed hole of the water pump
Visually check
Check leaks after about ten-minute warming up.
If coolant still leaks, replace a water pump.
If leakage stops, reuse the water pump (Do not replace the pump with a new one).
From gaskets or bolts
Check the tightening of the water pump mounting bolts.
Retighten the mounting bolts.
Check damage of gaskets or inflow of dust.
Replace the gasket and clean dust off.
From outer surface of water pump
Check the material or any cracks of the water pump.
Poor material. If any crack found, replace the water pump.
Noise
From bearings
From mechanical seals
Impeller interference
Inspection with a stethoscope
After starting the engine, check noise with a stethoscope.
If there is no noise, reuse the water pump(do not replace it).
If there is any noise from the water pump, remove the drive belt and recheck.
Inspection after removing a drive belt
After removing a water pump and a drive belt, check noise again.
If there is noise, reuse the water pump. Check other drive line parts.
If there is no noise, replace the water pump with a new one.
Inspection after removing a water pump
After removing a water pump and a drive belt, check noise again.
If there is any interference between them, replace the water pump with a new one.
Overheating
Damaged impeller
Loosened impeller
Loosened impeller
Corrosion of the impeller wing
Check engine coolant.
Poor coolant quality / Maintenance check
Impeller seperation from the shaft
Replace the water pump.

    Water pump Repair procedures
    Removal 1. Loosen the drain plug (A), and drain the engine coolant. Remove the radiator cap to drain with speed.     System is under high pressure when the engine is hot.To avoi ...

    Thermostat Components and Components Location
    Components 1. Water inlet fitting2. Thermostat ...

    See also:

    Crankshaft Position Sensor (CKPS). Troubleshooting
    Wave Form ...

    Stop Lamp Switch Schematic Diagrams
    Schematic Diagram System Circuit Diagram Terminal function TeminalDescription1IGN12Engine Control Module (ECM)3B+4Stop Lmap ...

    Power Window Switch Repair procedures
    Inspection Diagnosis with GDS 1. The body electrocal system can be quickly diagnosed failed parts with vehicle diagnostic system (GDS). The diagnostic system (GDS) provides the following informa ...