Hyundai Sonata: Brake Line. Repair procedures - Brake System - Brake SystemHyundai Sonata: Brake Line. Repair procedures

Removal

1.
Disconnect the brake fiuid level switch connector, and remove the reservoir cap.
2.
Remove the brake fluid from the master cylinder reservior with a syringe.
Do not spill brake fluid on the vehicle, it may damage the paint; if brake fluid does contact the paint, wash it off immediately with water.
3.
Remove the wheel & tire.
4.
Remove the brake hose clip (A).
Front

Rear
5.
Disconnect the brake tube by loosening the tube flare nut (B).
Tightening torque:
13.7 ~ 16.7N.m (1.4 ~ 1.7kgf.m, 10.1 ~ 12.3lb-ft)
6.
Disconnect the brake hose from the brake caliper by loosening the bolt (C).
Tightening torque:
24.5 ~29.4 N.m (2.5 ~3.0 kgf.m, 18.1 ~21.7 lb-ft)
Front

Rear

Inspection

1.
Check the brake tubes for cracks, crimps and corrosion.
2.
Check the brake hoses for cracks, damage and fluid leakage.
3.
Check the brake tube flare nuts for damage and fluid leakage.
4.
Check brake hose mounting bracket for crack or deformation.

Installation

1.
Installation is the reverse of removal.
Use a new washer (A) whenever installing.

2.
After installation, bleed the (Refer to Brake system bleeding)
3.
Check the spilled brake oil.

    Brake Pedal. Components and Components Location
    Components 1. Cowl bracket 2. Brake pedal member assembly 3. Stop lamp switch 4. Return spring 5. Brake pedal stopper 6. Clevis pin 7. Snap pin 8. Brak ...

    See also:

    Front Impact Sensor (FIS). Description and Operation
    Description The front impact sensor (FIS) is installed in the Front End Module (FEM). They are remote sensors that detect acceleration due to a collision at its mounting location. The primar ...

    Rear combination lamp. Repair procedures
    Removal 1. Disconnect the negative (-) battery terminal. 2. Remove the rear combination lamp cover (A). 3. ...

    Power Door Mirror Actuator. Repair procedures
    Inspection 1. Remove the front door quadrant delta cover. (Refer to the BD group - "Front door") 2. Disconnect the power door ...