Hyundai Sonata: Canister Close Valve (CCV). Repair procedures - Engine Control System - Engine Control/Fuel System

Hyundai Sonata: Canister Close Valve (CCV). Repair procedures

Hyundai Sonata YF 2011-2014 Service Manual / Engine Control/Fuel System / Engine Control System / Canister Close Valve (CCV). Repair procedures

Inspection

1.	Turn the ignition switch OFF.

2.	Disconnect the CCV connector.

3.	Measure resistance between the CCV terminal 1 and 2.

4.

Check that the resistance is within the specification.

Specification: Refer to "Specification"

5.	Disconnect the vapor hose connected with the canister from the CCV.

6.	Connect a vacuum pump to the nipple.

7.	Ground the CCV control line and apply battery voltage to the CCV power supply line.

8.

Apply vacuum and check the valve operation.

Specification: Vacuum maintained

Removal

1.	Turn the ignition switch OFF and disconnect the battery negative (-) cable.

2.	Disconnect the canister close valve connector (A).

3.	Disconnect the ventilation tube quick connector (B).

4.	Release the lever (C), and then remove the fuel tank air filter (D) after rotating it in the direction of the arrow in the figure.

5.	Release the lever (E), and then remove the canister close valve (F) after rotating it in the direction of the arrow in the figure.

Installation

•	Install the component with the specified torques.

•	Note that internal damage may occur when the component is dropped. If the component has been dropped, inspect before installing.

1.	Installation is reverse of removal.

Canister Close Valve (CCV). Schematic Diagrams

Circuit Diagram ...

Fuel Delivery System

...

See also:

How vehicle audio works
AM and FM radio signals are broadcast from transmitter towers located around your city. They are intercepted by the radio antenna on your vehicle. This signal is then received by the radio and s ...

Gauges
Speedometer The speedometer indicates the speed of the vehicle. The speedometer is calibrated in miles per hour and/or kilometers per hour. Tachometer The tachometer indicates the approxim ...

Description and Operation
Description Emissions Control System consists of three major systems. • The Crankcase Emission Control System prevents blow-by gas from releasing into the atmosphere. T ...