Hyundai Sonata: Stop Signal Electronic Module Repair procedures - Brake System - Brake SystemHyundai Sonata: Stop Signal Electronic Module Repair procedures

Inspection
1. Fuse inspection
Mount the test fuse to the switch fuse and relay fuse part to confirm a normal joint fit.

2. Inspection of connector by each part
Check to see whether or not each connector has been damaged, or terminal surge, or incomplete connection has taken place
[Engine room junction box]

[Stop signal electronic module]

[ABS/VDC control module]

3. Inspect the stop lamp circuit
Connect probe to each terminal wire and confirm oscilloscope waveform.
[Stop lamp switch input/output]

[Stop signal electronic module input/output]

[Oscilloscope waveform screen]

Removal
1.
Turn ignition switch OFF and disconnect the negative (-) battery cable.
2.
Remove the AVN unit.
(Refer to Body Electrical System - "AVN sytem" )
(Refer to Body Electrical System - "Premium AVN System")
3.
Remove the glove box.
(Refer to Body - "Glove Box" )
4.
Disconnect the stop signal electronic module connector (A).
5.
Remove the clip (B) and then remove the stop signal electronic module.

6.
Installation is the reverse of removal.
    Stop Signal Electronic Module Schematic Diagrams
    System Circuit Diagram Terminal Function TeminalDescription1Ground 2HAC/DBC Signal (Active Low)3ESS Signal (Active Low)4Stop lamp5Stop lamp switch6ECU/ SMK7ESS Signal (Active High)8Battery ...

    See also:

    Occupant Classification Sensor (OCS) Repair procedures
    Removal OCS ECU 1. Disconnect the battery negative cable, and wait for at least three minutes before beginning work. 2. Remove the front passenger seat assembly. (Refer to Body - "Front Sea ...

    Start/Stop Button Repair procedures
    Removal 1. Disconnect the negative(-) battery terminal. 2. Remove the center facia panel. (Refer to Heating, Ventilation and Air Conditioning - "Controller") 3. Remove the start/stop butt ...

    SRS Care
    The SRS is virtually maintenance-free and so there are no parts you can safely service by yourself. If the SRS air bag warning light "" does not illuminate, when you turn the ignition on ...